Roof - what should happen?

J

Jezza21

Member
So yesterday I got my roof motor out, now when I connect it to a battery it sounds very nicely! DIY removal and refurb was absolutely worth it. I encourage anyone thinking about it to do it!!

However after connecting it back up in the boot, nothing happens at all. No noise, the windows don't even drop in preparation for the roof to open!

So there must be an electrical problem - if the windows aren't even dropping when I press the roof open button, is this likely to be because the circuit is "incomplete", I.e there is a break somewhere in the boot cables? Or am i facing a bigger electrical problem?
 
I don't even have the parcel shelf in the car right now, it's still off from when I needed access to my motor for removal

What's this micro switch?
 
The shelf when in the lower position hits the mircoswitch an allows the roof to work , sounds likely this is the issue
 
The micro switch is in the middle of the rear bulkhead towards the top, if yes press an hold it in an get some one to press roof button or press an hold unlock on your keys it should work
 
if the shelf isnt fitted then i think the car will think its up and therefore not let you operate the roof. Step in any time Mike (DLV) :thumbsup:
 
Bingo this is the problem! It's running. Now the new problem, how do I fit the parcel shelf without damaging the roof motor hydraulic cables! Does everyone cut out slots or something?

I feel the frame that holds the parcel shelf on the left will not fit over these cables
 
You would have been getting an orange light when you pressed the "lower" button. This indicates that the shelf is up, or not fitted, and is a safety measure.

Mike
 
That's exactly it Mike, good to know. Thanks!

Mine's connected and spinning, don't think it has enough oil in it though. Roof unlocks but doesn't actually move.

Even though it's still not fixed I'm feeling great just to have the bugger out and re connected! Very satisfying after so many rude words and shouting at damn cable ties haha!
 
You must log in or register to reply here.
Back
Top Bottom